Pass rate
67.3%
Below average — 5.1 pts behind the 72.4% that cars this age and mileage manage.
Across 9,221 recorded tests.
Typical repair bill £66–£176
2005 Ford Ka MOT pass rate
- 2005
- typical 51,384 mi
Check your postcode
Most common fault
Suspension
30.7% of faults · 21.0% nationally
mostly worn arm bushes, split ball-joint boots and broken coil springs.
Part only £35–£75 for Suspension pin or bush excessively worn. What fitting it takes →
18.6 pts down across model years — 22.0% in 2001, 3.4% in 2016.
Which year to buy
- Best 2019 92.6% pass
- Avoid 2008 66.2% pass
Across the 20 years on record, a spread of 26.4 points. See every year →
- First-attempt pass
- 57.9%
- Typical mileage
- 51k mi
The 2005 Ford Ka MOT pass rate is 67.3% of its MOT tests — 5.1 points behind what its age and mileage predict. Suspension is the biggest single reason it fails, at 30.7% of what testers record.
Expert verdict
Suspension: 1.5× the national share
Suspension accounts for 30.7% of everything recorded on the 2005 Ford Ka, against 21.0% nationally — 9.7 points above. Ask for the front and rear suspension to be checked on a ramp before you buy — worn bushes and broken springs are cheap to look at and expensive to discover at test time.
- Falls short of its own age and mileage. Like-for-like, cars this age and mileage expect about 72.4%; this one manages 67.3% — 5.1 points below. Age is a fair excuse; this is not age.
Written from this page's own figures: fault shares against the national composition, the like-for-like pass rate, and the priced repair list. How these are worked out
Watching a Ford Ka? Get an email when these numbers change .
How does the 2005 Ford Ka compare?
Cars of this age and mileage average 72.4%, so this figure is 5.1 points behind what its age and mileage predict. On a first attempt, before any retests, the figure drops to 57.9%. The median 2005 Ford Ka in this dataset had covered 51,384 mi.
Pass rates also shift with the test month: tests recorded October–March passed 67.0% of the time, April–September 67.5%.
The single most recorded failure item is "Component mounting prescribed areas prescribed area excessively corroded significantly reducing structural strength", noted on 10.00% of tests.
- 9,221 recorded tests behind this page.
- 67.3% overall pass rate, 57.9% on a first attempt.
- Across every year of the Ford Ka, the average is 78.0% — best year 2019 (92.6%), worst 2008 (66.2%).
Figures count every completed test on this vehicle-year in the dataset, including retests. See methodology for the exact definition.
This page's data
- Tests analysed
- 9,221
- Typical mileage (median)
- 51,384 mi
- Make and model
- Ford Ka
- Updated
- 2026-11-07
Source: DVSA anonymised MOT test data (2023–2025), OGL v3.0.
Top part to budget for
Corrosion Welding Repair
Typically a garage job — get quotes before committing.
Does mileage affect the Ka MOT pass rate?
Pass rate by odometer reading. Bar lengths start at 52% so small gaps stay visible.
Where the Ford Ka is most common
Across all Ka model years on record (2000–2019): 253,674 Ford Ka cars tested in a recordable postcode area, across 655,731 tests. Birmingham (B) has the most, with 8,526 cars tested there. Cars are counted by the postcode area of the MOT station, so this is where they were tested, not necessarily where their owners live.
| # | Postcode area | Cars | Pass rate |
|---|---|---|---|
| 1 | Birmingham (B) | 8,526 | 79.9% |
| 2 | Sheffield (S) | 5,823 | 79.8% |
| 3 | Cardiff (CF) | 5,618 | 74.4% |
| 4 | Nottingham (NG) | 5,150 | 75.7% |
| 5 | Leicester (LE) | 4,977 | 80.4% |
| 6 | Bristol (BS) | 4,861 | 74.1% |
| 7 | Chelmsford (CM) | 4,617 | 80.8% |
| 8 | Basildon (SS) | 4,434 | 81.1% |
| 9 | Newcastle upon Tyne (NE) | 4,214 | 78.2% |
| 10 | Manchester (M) | 3,981 | 78.3% |
| 11 | Peterborough (PE) | 3,967 | 80.2% |
| 12 | Portsmouth (PO) | 3,930 | 76.3% |
| 13 | Norwich (NR) | 3,848 | 79.7% |
| 14 | Maidstone (ME) | 3,809 | 80.5% |
| 15 | Liverpool (L) | 3,781 | 79.4% |
| 16 | Derby (DE) | 3,751 | 79.2% |
| 17 | Coventry (CV) | 3,719 | 78.4% |
| 18 | Ashford (TN) | 3,568 | 79.3% |
| 19 | Romford (RM) | 3,508 | 85.0% |
| 20 | Doncaster (DN) | 3,455 | 78.6% |
The twenty areas with the most Ford Ka cars in the record, sorted by car count — sort the columns for a different question. Cars tested at a station whose postcode area could not be resolved are counted in the model's total but in no area, so the shares add up to slightly under 100% even across every area, and an area's cars are a subset of the model's. Pass rate is blank below 30 tests in an area, where a percentage is noise rather than a finding. How this model's pass rate varies by postcode →
Regional pass rates for the Ka
| Region | Tests | Pass rate |
|---|---|---|
| South East | 2,551 | 69.5% |
| East of England | 1,382 | 67.3% |
| South West | 1,363 | 62.8% |
| West Midlands | 929 | 68.0% |
| North West | 801 | 65.3% |
| East Midlands | 619 | 67.5% |
| London | 513 | 73.7% |
| Yorkshire | 483 | 66.5% |
| Wales | 280 | 61.4% |
| North East | 168 | 67.9% |
| Scotland | 125 | 64.8% |
Regions come from the postcode area recorded at the test station. Areas on region borders are assigned to the region with the majority of their population.
What fails a 2005 Ka
Everything a tester recorded on this vehicle, grouped into the inspection sections that produced it. The notch on each bar is the national share, so you can see at a glance whether this car is unusual or just ordinary.
A test can record several items, so these percentages do not add up to 100%. The exact strings, with prices, are in the full DVSA record at the bottom of this page.
Before your test
Three checks worth doing on a 2005 Ka
These are not generic tips — they are the faults recorded most often on this exact model, rewritten as things you can check yourself. All three take about ten minutes and cost nothing.
-
Check corrosion 10.0% of tests
“component mounting prescribed areas prescribed area excessively corroded significantly reducing structural strength”
Look under the sills, around the jacking points and where the suspension mounts meet the body. Flaking, holed or crumbly metal fails; a brown stain on sound metal does not.
-
Check the suspension joints 5.6% of tests
“pins and bushes pin or bush excessively worn”
With the car parked on level ground, rock the top of each front wheel in and out while someone watches the suspension arm. Clunks, or rubber boots split and greasy, are what testers record here.
-
Check the coil springs 5.0% of tests
“coil spring fractured or broken”
Look up inside each wheel arch with a torch, all the way round the spring. A snapped spring usually breaks at the very bottom coil, where a quick glance will not reach.
Shares are the proportion of tests on this vehicle that recorded the item, so they overlap: one test can record several.
What it costs to get a 2005 Ka through its MOT
Across the 10 items that are recorded most often on this model, the average repair comes to £66–£176 — and 36% of those repairs are parts that cost under £30.
- Average repair across the 10 common items
- £66–£176
- Cheapest common item: malfunction indicator lamp inoperative or…
- £3–£12
- Dearest common item: component mounting prescribed areas…
- £180–£450
- Common items a careful owner can do at home
- 60%
- Repairs that still cost under £30
- 36%
Estimates from typical UK parts prices, weighted by how often each item appears in 9,221 MOT tests on this vehicle. They exclude diagnostics, retest fees and garage labour where the part is a DIY fit, and they are not figures from the DVSA dataset. Older and higher-mileage examples cost more than the average. How these estimates are built → · All MOT repair costs → · Cheapest cars to put through a test →
Every year of the Ka, side by side
20 model years on record, from 2000 to 2019. Across them the pass rate runs from 66.2% to 92.6% — a spread of 26.4 points. The bar under each year is the item that failed it most often.
- 2000 69.7% component mounting prescribed…
- 2001 66.3% component mounting prescribed…
- 2002 67.2% component mounting prescribed…
- 2003 68.0% component mounting prescribed…
- 2004 66.7% component mounting prescribed…
- 2005 67.3%component mounting prescribed…
- 2006 66.8% component mounting prescribed…
- 2007 66.4% component mounting prescribed…
- 2008 66.2% component mounting prescribed…
- 2009 71.9% rbt (sp) efficiency below…
- 2010 72.8% rbt (sp) efficiency below…
- 2011 75.6% ball joint excessively worn
- 2012 77.5% pins and bushes pin or bush…
- 2013 79.1% pins and bushes pin or bush…
- 2014 80.9% shock absorbers has a serious…
- 2015 80.6% shock absorbers has a serious…
- 2016 82.5% coil spring fractured or broken
- 2017 89.5% headlamp not working on dipped…
- 2018 88.7% track rod end ball joint has…
- 2019 92.6% windscreen damaged but not…
Colour is the pass rate on a fixed scale, so a block means the same thing on any model. Each year links to its own page with the full fault breakdown.
Compare the 2005 Ford Ka with another year
The raw pass rate mostly measures age. The year comparison adds the like-for-like figure, the mileage bands and the repair bill.
Other 2005 cars with a similar record
- Kia Sportage 67.3%
- Vauxhall Meriva 67.6%
- Suzuki Alto 67.7%
- Vauxhall Combo 67.8%
- Renault Modus 67.9%
- Renault Clio 68.0%
Closest pass rates among 2005 cars with at least 2,000 tests, so a small sample cannot flatter itself into the list. See the full rankings: best and worst MOT pass rates.
The full DVSA record for the 2005 Ford Ka 10 failure items · 6 advisories · 10 inspection categories · mileage brackets · all of it in the page, none of it above the fold
Every inspection category
Shares of the 26,723 individual items recorded on this vehicle, and the same share across all cars nationally. A single test can record several items, so a row is not a percentage of tests.
| Category | Items | This car | Nationally | Difference |
|---|---|---|---|---|
| Suspension | 8,485 | 30.70% | 20.98% | +9.72 |
| Brakes | 3,446 | 12.50% | 20.89% | −8.39 |
| Tyres | 3,143 | 11.40% | 19.76% | −8.36 |
| Lamps, reflectors and electrical equipment | 3,060 | 11.10% | 12.21% | −1.11 |
| Noise, emissions and leaks | 2,792 | 10.10% | 5.52% | +4.58 |
| Body, chassis, structure | 2,696 | 9.80% | 5.57% | +4.23 |
| Visibility | 1,169 | 4.20% | 4.97% | −0.77 |
| Road Wheels | 725 | 2.60% | 0.75% | +1.85 |
| Seat belts and supplementary restraint systems | 703 | 2.50% | 0.82% | +1.68 |
| Steering | 504 | 1.80% | 2.57% | −0.77 |
The exact failure items, in the tester's words
| Recorded item | Severity | Tests | Est. cost |
|---|---|---|---|
| Component mounting prescribed areas prescribed area excessively corroded significantly reducing structural strength Suspension | Major | 10.0% | £180–450 |
| Pins and bushes pin or bush excessively worn Suspension | Major | 5.6% | £40–150 |
| Coil spring fractured or broken Suspension | Major | 5.0% | £25–65 |
| Registration plate lamp(s) inoperative in the case of multiple lamps or light sources Lamps, reflectors and electrical equipment | Minor | 4.9% | £5–20 |
| Prescribed areas prescribed area strength or continuity significantly reduced Seat belts and supplementary restraint systems | Major | 4.9% | £40–120 |
| Malfunction indicator lamp inoperative or indicates a malfunction Noise, emissions and leaks | Major | 3.0% | £3–12 |
| Stop lamp not working Lamps, reflectors and electrical equipment | Major | 2.6% | £3–12 |
| Wipers does not clear the windscreen effectively Visibility | Major | 2.6% | £8–22 |
| Chassis condition or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Body, chassis, structure | Major | 2.4% | £180–450 |
| Position lamp not working Lamps, reflectors and electrical equipment | Major | 2.3% | £5–25 |
Severity is as recorded: Major and Dangerous fail the test outright; Minor and Advisory do not. Costs are estimates from typical UK parts prices — see how they are built.
What testers noted without failing the car
Advisories are the early warnings — the same parts a year or two before they fail. Reading them is how you tell a car that has been maintained from one that has been patched.
| Recorded item | Severity | Tests | Est. cost |
|---|---|---|---|
| Pins and bushes pin or bush excessively worn Suspension | Advisory | 23.6% | £40–150 |
| Engine oil leaks leaking excessively from engine Noise, emissions and leaks | Advisory | 20.6% | £200–700 |
| Has a tear, caused by separation or partial failure of its structure Tyres | Advisory | 13.2% | £45–95 |
| Tread depth below requirements of 1.6mm Tyres | Advisory | 13.0% | £45–95 |
| Component mounting prescribed areas prescribed area excessively corroded significantly reducing structural strength Suspension | Advisory | 11.2% | £180–450 |
| Brake discs in such a condition that it is seriously weakened Brakes | Advisory | 8.7% | £45–110 |
Pass rate by mileage
| Mileage | Tests | Pass rate | Median odometer |
|---|---|---|---|
| 0-30k | 1,449 | 76.1% | 21,979 mi |
| 30-60k | 4,420 | 67.9% | 45,279 mi |
| 60-90k | 2,721 | 63.0% | 72,320 mi |
| 90-120k | 548 | 61.5% | 100,276 mi |
| 120k+ | 75 | 60.0% | 132,823 mi |
Source: 9,221 recorded tests on this vehicle-year. Every row above is recomputed from the same DVSA extract as the rest of the page — see the methodology.
2005 Ka MOT questions
What is the MOT pass rate for a 2005 Ford Ka?
67.3% of the 9,221 2005 Ford Ka tests in this dataset passed, against a national average of 72.4% for cars first used in 2005. First-attempt pass rate: 57.9%.
What are the most common MOT failures on a 2005 Ford Ka?
The three most recorded items are component mounting prescribed areas prescribed area excessively corroded significantly reducing structural strength (10.00%), pins and bushes pin or bush excessively worn (5.59%), coil spring fractured or broken (4.97%). Percentages are the share of tests on this vehicle that recorded the item.
Does mileage affect the 2005 Ford Ka MOT pass rate?
Yes. Cars under 30,000 miles passed 76.1% of the time, falling to 60.0% for those over 120,000 miles. The median 2005 Ford Ka in this dataset had covered 51,384 mi.
Does the season affect the 2005 Ford Ka MOT pass rate?
Tests recorded in the winter months (October–March) passed 67.0% of the time; summer months (April–September) passed 67.5%. Brakes, tyres and lights are tested harder in bad weather, but the difference is small on most models.