Pass rate
67.8%
Below average — 4.4 pts behind the 72.2% that cars this age and mileage manage.
Across 10,055 recorded tests.
Typical repair bill £64–£172
2004 Fiat Panda MOT pass rate
- 2004
- typical 78,296 mi
Check your postcode
Most common fault
Suspension
29.5% of faults · 21.0% nationally
mostly worn arm bushes, split ball-joint boots and broken coil springs.
Part only £35–£75 for Suspension pin or bush excessively worn. What fitting it takes →
2.9 pts down across model years — 5.1% in 2004, 2.2% in 2020.
Which year to buy
- Best 2022 92.7% pass
- Avoid 2004 67.8% pass · this year
Across the 20 years on record, a spread of 24.9 points. See every year →
- First-attempt pass
- 56.3%
- Typical mileage
- 78k mi
The 2004 Fiat Panda MOT pass rate is 67.8% of its MOT tests — 4.4 points behind what its age and mileage predict. Suspension is the biggest single reason it fails, at 29.5% of what testers record.
Expert verdict
Suspension: 1.4× the national share
Suspension accounts for 29.5% of everything recorded on the 2004 Fiat Panda, against 21.0% nationally — 8.5 points above. Ask for the front and rear suspension to be checked on a ramp before you buy — worn bushes and broken springs are cheap to look at and expensive to discover at test time.
- Falls short of its own age and mileage. Like-for-like, cars this age and mileage expect about 72.2%; this one manages 67.8% — 4.4 points below. Age is a fair excuse; this is not age.
- When it fails, it costs. Only 7% of this model’s typical repairs come in under £30 in parts — the failures here tend to be the kind that need a garage rather than a bulb.
Written from this page's own figures: fault shares against the national composition, the like-for-like pass rate, and the priced repair list. How these are worked out
Watching a Fiat Panda? Get an email when these numbers change .
How does the 2004 Fiat Panda compare?
Cars of this age and mileage average 72.2%, so this figure is 4.4 points behind what its age and mileage predict. On a first attempt, before any retests, the figure drops to 56.3%. The median 2004 Fiat Panda in this dataset had covered 78,296 mi.
Pass rates also shift with the test month: tests recorded October–March passed 67.5% of the time, April–September 68.2%.
The single most recorded failure item is "Rbt (sp) efficiency below requirements", noted on 5.64% of tests.
- 10,055 recorded tests behind this page.
- 67.8% overall pass rate, 56.3% on a first attempt.
- Across every year of the Fiat Panda, the average is 76.3% — best year 2022 (92.7%), worst 2004 (67.8%).
Figures count every completed test on this vehicle-year in the dataset, including retests. See methodology for the exact definition.
This page's data
- Tests analysed
- 10,055
- Typical mileage (median)
- 78,296 mi
- Make and model
- Fiat Panda
- Updated
- 2026-11-07
Source: DVSA anonymised MOT test data (2023–2025), OGL v3.0.
Top part to budget for
Brake Discs and Pads Set
Usually a DIY or independent-garage job.
Does mileage affect the Panda MOT pass rate?
Pass rate by odometer reading. Bar lengths start at 53% so small gaps stay visible.
Where the Fiat Panda is most common
Across all Panda model years on record (2003–2022): 119,635 Fiat Panda cars tested in a recordable postcode area, across 329,086 tests. Sheffield (S) has the most, with 2,971 cars tested there. Cars are counted by the postcode area of the MOT station, so this is where they were tested, not necessarily where their owners live.
| # | Postcode area | Cars | Pass rate |
|---|---|---|---|
| 1 | Sheffield (S) | 2,971 | 78.7% |
| 2 | Birmingham (B) | 2,565 | 79.5% |
| 3 | Newcastle upon Tyne (NE) | 2,394 | 76.6% |
| 4 | Bristol (BS) | 2,222 | 72.9% |
| 5 | Brighton (BN) | 2,219 | 76.0% |
| 6 | Swansea (SA) | 2,099 | 75.8% |
| 7 | Stoke On Trent (ST) | 2,050 | 76.3% |
| 8 | Ashford (TN) | 1,958 | 77.7% |
| 9 | Norwich (NR) | 1,956 | 77.4% |
| 10 | Portsmouth (PO) | 1,898 | 76.4% |
| 11 | Cardiff (CF) | 1,888 | 74.5% |
| 12 | Exeter (EX) | 1,802 | 73.6% |
| 13 | Coventry (CV) | 1,798 | 80.0% |
| 14 | Edinburgh (EH) | 1,793 | 70.1% |
| 15 | Plymouth (PL) | 1,755 | 74.0% |
| 16 | Glasgow (G) | 1,716 | 71.1% |
| 17 | Nottingham (NG) | 1,640 | 73.9% |
| 18 | Manchester (M) | 1,568 | 77.9% |
| 19 | Northampton (NN) | 1,538 | 77.6% |
| 20 | Truro (TR) | 1,532 | 72.1% |
The twenty areas with the most Fiat Panda cars in the record, sorted by car count — sort the columns for a different question. Cars tested at a station whose postcode area could not be resolved are counted in the model's total but in no area, so the shares add up to slightly under 100% even across every area, and an area's cars are a subset of the model's. Pass rate is blank below 30 tests in an area, where a percentage is noise rather than a finding. How this model's pass rate varies by postcode →
Regional pass rates for the Panda
| Region | Tests | Pass rate |
|---|---|---|
| South East | 2,562 | 70.3% |
| South West | 1,633 | 63.7% |
| East of England | 1,140 | 70.3% |
| North West | 1,022 | 68.8% |
| West Midlands | 925 | 68.9% |
| Yorkshire | 779 | 65.0% |
| East Midlands | 535 | 66.9% |
| London | 446 | 74.4% |
| Wales | 422 | 65.2% |
| Scotland | 384 | 60.2% |
| North East | 207 | 63.8% |
Regions come from the postcode area recorded at the test station. Areas on region borders are assigned to the region with the majority of their population.
What fails a 2004 Panda
Everything a tester recorded on this vehicle, grouped into the inspection sections that produced it. The notch on each bar is the national share, so you can see at a glance whether this car is unusual or just ordinary.
A test can record several items, so these percentages do not add up to 100%. The exact strings, with prices, are in the full DVSA record at the bottom of this page.
Before your test
Three checks worth doing on a 2004 Panda
These are not generic tips — they are the faults recorded most often on this exact model, rewritten as things you can check yourself. All three take about ten minutes and cost nothing.
-
Check corrosion 4.6% of tests
“component mounting prescribed areas prescribed area excessively corroded significantly reducing structural strength”
Look under the sills, around the jacking points and where the suspension mounts meet the body. Flaking, holed or crumbly metal fails; a brown stain on sound metal does not.
-
Check the suspension joints 3.9% of tests
“pins and bushes pin or bush excessively worn”
With the car parked on level ground, rock the top of each front wheel in and out while someone watches the suspension arm. Clunks, or rubber boots split and greasy, are what testers record here.
-
Check the shock absorbers 3.5% of tests
“shock absorbers has a serious fluid leak”
Press down hard on each corner of the car and let go. It should settle in one bounce; if it keeps rocking, or you can see oil weeping down a shock absorber, that is the fault a tester will find.
Shares are the proportion of tests on this vehicle that recorded the item, so they overlap: one test can record several.
What it costs to get a 2004 Panda through its MOT
Across the 10 items that are recorded most often on this model, the average repair comes to £64–£172 — and 7% of those repairs are parts that cost under £30.
- Average repair across the 10 common items
- £64–£172
- Cheapest common item: wipers does not clear the windscreen…
- £8–£22
- Dearest common item: component mounting prescribed areas…
- £180–£450
- Common items a careful owner can do at home
- 40%
- Repairs that still cost under £30
- 7%
Estimates from typical UK parts prices, weighted by how often each item appears in 10,055 MOT tests on this vehicle. They exclude diagnostics, retest fees and garage labour where the part is a DIY fit, and they are not figures from the DVSA dataset. Older and higher-mileage examples cost more than the average. How these estimates are built → · All MOT repair costs → · Cheapest cars to put through a test →
Every year of the Panda, side by side
20 model years on record, from 2003 to 2022. Across them the pass rate runs from 67.8% to 92.7% — a spread of 24.9 points. The bar under each year is the item that failed it most often.
- 2003 67.8% pins and bushes pin or bush…
- 2004 67.8%rbt (sp) efficiency below…
- 2005 69.2% rbt (sp) efficiency below…
- 2006 69.2% rbt (sp) efficiency below…
- 2007 69.8% pins and bushes pin or bush…
- 2008 70.3% pins and bushes pin or bush…
- 2009 72.4% pins and bushes pin or bush…
- 2010 72.6% pins and bushes pin or bush…
- 2011 73.8% pins and bushes pin or bush…
- 2012 77.4% registration plate lamp(s)…
- 2013 78.4% coil spring fractured or broken
- 2014 80.1% registration plate lamp(s)…
- 2015 81.4% registration plate lamp(s)…
- 2016 83.5% shock absorbers has an…
- 2017 85.4% coil spring fractured or broken
- 2018 87.3% coil spring fractured or broken
- 2019 89.1% coil spring fractured or broken
- 2020 92.3% coil spring fractured or broken
- 2021 92.0% coil spring fractured or broken
- 2022 92.7% pins and bushes pin or bush…
Colour is the pass rate on a fixed scale, so a block means the same thing on any model. Each year links to its own page with the full fault breakdown.
Compare the 2004 Fiat Panda with another year
The raw pass rate mostly measures age. The year comparison adds the like-for-like figure, the mileage bands and the repair bill.
Other 2004 cars with a similar record
- Citroen C2 68.0%
- Peugeot 307 68.1%
- Vauxhall Meriva 67.4%
- Suzuki Alto 67.4%
- Volkswagen Polo 68.3%
- Renault Clio 68.3%
Closest pass rates among 2004 cars with at least 2,000 tests, so a small sample cannot flatter itself into the list. See the full rankings: best and worst MOT pass rates.
The full DVSA record for the 2004 Fiat Panda 10 failure items · 6 advisories · 10 inspection categories · mileage brackets · all of it in the page, none of it above the fold
Every inspection category
Shares of the 31,684 individual items recorded on this vehicle, and the same share across all cars nationally. A single test can record several items, so a row is not a percentage of tests.
| Category | Items | This car | Nationally | Difference |
|---|---|---|---|---|
| Suspension | 9,473 | 29.50% | 20.98% | +8.52 |
| Brakes | 4,901 | 15.30% | 20.89% | −5.59 |
| Tyres | 4,105 | 12.80% | 19.76% | −6.96 |
| Lamps, reflectors and electrical equipment | 3,590 | 11.20% | 12.21% | −1.01 |
| Noise, emissions and leaks | 3,423 | 10.70% | 5.52% | +5.18 |
| Body, chassis, structure | 2,639 | 8.20% | 5.57% | +2.63 |
| Visibility | 1,375 | 4.30% | 4.97% | −0.67 |
| Non-component advisories | 771 | 2.40% | 4.18% | −1.78 |
| Identification of the vehicle | 735 | 2.30% | 1.76% | +0.54 |
| Steering | 672 | 2.10% | 2.57% | −0.47 |
The exact failure items, in the tester's words
| Recorded item | Severity | Tests | Est. cost |
|---|---|---|---|
| Rbt (sp) efficiency below requirements Brakes | Major | 5.6% | £45–110 |
| Component mounting prescribed areas prescribed area excessively corroded significantly reducing structural strength Suspension | Major | 4.6% | £180–450 |
| Pins and bushes pin or bush excessively worn Suspension | Major | 3.9% | £40–150 |
| Shock absorbers has a serious fluid leak Suspension | Major | 3.5% | £30–75 |
| Service brake imbalance across an axle Brakes | Major | 3.3% | £45–110 |
| Exhaust system has a major leak of exhaust gases Body, chassis, structure | Major | 2.9% | £45–120 |
| Parking brake performance inoperative on one side Brakes | Major | 2.8% | £60–150 |
| Windscreen damaged but not adversely affecting driver's view Visibility | Minor | 2.4% | £80–200 |
| Wipers does not clear the windscreen effectively Visibility | Major | 2.4% | £8–22 |
| Catalyst emissions Lambda reading after 2nd fast idle outside specified limits Noise, emissions and leaks | Major | 2.3% | £60–250 |
Severity is as recorded: Major and Dangerous fail the test outright; Minor and Advisory do not. Costs are estimates from typical UK parts prices — see how they are built.
What testers noted without failing the car
Advisories are the early warnings — the same parts a year or two before they fail. Reading them is how you tell a car that has been maintained from one that has been patched.
| Recorded item | Severity | Tests | Est. cost |
|---|---|---|---|
| Engine oil leaks leaking excessively from engine Noise, emissions and leaks | Advisory | 23.3% | £200–700 |
| Tread depth below requirements of 1.6mm Tyres | Advisory | 21.4% | £45–95 |
| Coil spring corroded so that its cross sectional area is reduced and seriously weakened Suspension | Advisory | 21.3% | £25–65 |
| Pins and bushes pin or bush excessively worn Suspension | Advisory | 11.3% | £40–150 |
| Has a tear, caused by separation or partial failure of its structure Tyres | Advisory | 10.7% | £45–95 |
| Exhaust system has a major leak of exhaust gases Body, chassis, structure | Advisory | 10.3% | £45–120 |
Pass rate by mileage
| Mileage | Tests | Pass rate | Median odometer |
|---|---|---|---|
| 0-30k | 352 | 77.3% | 22,415 mi |
| 30-60k | 2,389 | 73.7% | 47,509 mi |
| 60-90k | 3,789 | 68.0% | 75,310 mi |
| 90-120k | 2,446 | 63.1% | 102,981 mi |
| 120k+ | 1,066 | 61.5% | 139,340 mi |
Source: 10,055 recorded tests on this vehicle-year. Every row above is recomputed from the same DVSA extract as the rest of the page — see the methodology.
2004 Panda MOT questions
What is the MOT pass rate for a 2004 Fiat Panda?
67.8% of the 10,055 2004 Fiat Panda tests in this dataset passed, against a national average of 72.2% for cars first used in 2004. First-attempt pass rate: 56.3%.
What are the most common MOT failures on a 2004 Fiat Panda?
The three most recorded items are rbt (sp) efficiency below requirements (5.64%), component mounting prescribed areas prescribed area excessively corroded significantly reducing structural strength (4.63%), pins and bushes pin or bush excessively worn (3.88%). Percentages are the share of tests on this vehicle that recorded the item.
Does mileage affect the 2004 Fiat Panda MOT pass rate?
Yes. Cars under 30,000 miles passed 77.3% of the time, falling to 61.5% for those over 120,000 miles. The median 2004 Fiat Panda in this dataset had covered 78,296 mi.
Does the season affect the 2004 Fiat Panda MOT pass rate?
Tests recorded in the winter months (October–March) passed 67.5% of the time; summer months (April–September) passed 68.2%. Brakes, tyres and lights are tested harder in bad weather, but the difference is small on most models.