Pass rate
87.0%
Above average — 5.0 pts behind the 92.0% that cars this age and mileage manage.
Across 5,018 recorded tests.
Typical repair bill £30–£79
2022 Ford Tourneo Custom MOT pass rate
- 2022
- People carrier
- 14 trims combined
- typical 36,917 mi
Most common fault
Brakes
25.3% of faults · 20.9% nationally
mostly worn pads and discs, corroded pipes and a handbrake that will not hold.
Part only £25–£40 for Brake pads under 1.5 mm. What fitting it takes →
1.8 pts down across model years — 5.1% in 2018, 3.3% in 2022.
Which year to buy
- Best 2025 100.0% pass
- Avoid 2015 78.7% pass
Across the 11 years on record, a spread of 21.3 points. See every year →
- First-attempt pass
- 85.3%
- Typical mileage
- 37k mi
The 2022 Ford Tourneo Custom MOT pass rate is 87.0% of its MOT tests — 5.0 points behind what its age and mileage predict. Brakes is the biggest single reason it fails, at 25.3% of what testers record.
Check your postcode
MOT pass rates are national — type your postcode to see how Ford Tourneo Custom does in your corner of the country.
Expert verdict
Visibility: 2.9× the national share
Visibility accounts for 14.3% of everything recorded on the 2022 Ford Tourneo Custom, against 5.0% nationally — 9.3 points above. Brakes are still the single largest share at 25.3%, but at 20.9% nationally that one is ordinary. Wipers, washers and a chip in the driver’s eyeline are the three quickest ways to fail a test that the car otherwise deserves to pass.
- Falls short of its own age and mileage. Like-for-like, people carriers this age and mileage expect about 92.0%; this one manages 87.0% — 5.0 points below. Age is a fair excuse; this is not age.
Written from this page's own figures: fault shares against the national composition, the like-for-like pass rate, and the priced repair list. How these are worked out
Watching a Ford Tourneo Custom? Get an email when these numbers change .
Every Ford Tourneo Custom first registered in 2022 is combined here — 14 trim and body variants in total — so the sample is as large as the DVSA data allows.
How does the 2022 Ford Tourneo Custom compare?
Cars of this age and mileage average 92.0%, so this figure is 5.0 points behind what its age and mileage predict. On a first attempt, before any retests, the figure drops to 85.3%. The median 2022 Ford Tourneo Custom in this dataset had covered 36,917 mi.
88% of the tests on this vehicle ran on Diesel, which passed 86.6% of the time. Pass rates also shift with the test month: tests recorded October–March passed 88.1% of the time, April–September 86.2%.
The single most recorded failure item is "Windscreen damaged but not adversely affecting driver's view", noted on 3.13% of tests.
- 5,018 recorded tests behind this page.
- 87.0% overall pass rate, 85.3% on a first attempt.
- Across every year of the Ford Tourneo Custom, the average is 86.9% — best year 2025 (100.0%), worst 2015 (78.7%).
Figures count every completed test on this vehicle-year in the dataset, including retests. See methodology for the exact definition.
This page's data
- Tests analysed
- 5,018
- Typical mileage (median)
- 36,917 mi
- Make and model
- Ford Tourneo Custom
- Updated
- 2026-11-05
Source: DVSA anonymised MOT test data (2023–2025), OGL v3.0.
Top part to budget for
Windscreen
Typically a garage job — get quotes before committing.
Does mileage affect the Tourneo Custom MOT pass rate?
Pass rate by odometer reading. Bar lengths start at 73% so small gaps stay visible.
Fuel type and reliability
Pass rate by fuel type. Diesel is the most common here (88% of tests).
Regional pass rates for the Tourneo Custom
| Region | Tests | Pass rate |
|---|---|---|
| South East | 1,069 | 88.9% |
| North West | 597 | 83.2% |
| South West | 541 | 85.8% |
| East of England | 532 | 90.2% |
| West Midlands | 519 | 83.4% |
| Scotland | 506 | 88.7% |
| Yorkshire | 338 | 87.6% |
| East Midlands | 316 | 88.0% |
| Wales | 294 | 88.4% |
| North East | 179 | 87.2% |
| London | 127 | 82.7% |
Regions come from the postcode area recorded at the test station. Areas on region borders are assigned to the region with the majority of their population.
What fails a 2022 Tourneo Custom
Everything a tester recorded on this vehicle, grouped into the inspection sections that produced it. The notch on each bar is the national share, so you can see at a glance whether this car is unusual or just ordinary.
A test can record several items, so these percentages do not add up to 100%. The exact strings, with prices, are in the full DVSA record at the bottom of this page.
Before your test
Three checks worth doing on a 2022 Tourneo Custom
These are not generic tips — they are the faults recorded most often on this exact model, rewritten as things you can check yourself. All three take about ten minutes and cost nothing.
-
Check the windscreen 3.1% of tests
“windscreen damaged”
Check the driver’s side of the screen within the swept area for chips and cracks; anything larger than 10mm in the driver’s central view is a fail. Most chips can be resin-repaired for far less than a new screen.
-
Check the wipers and washers 3.0% of tests
“wipers does not clear the windscreen effectively”
Run the wipers with the screen wet: they should clear it in one sweep without smearing or juddering. Top the washer bottle up and check both jets hit the screen.
-
Check the lights 2.4% of tests
“registration plate lamp(s) inoperative in the case of multiple lamps or light sources”
Switch everything on and walk round the car: both headlamps on dip and main, every indicator, both brake lights, reverse, fog and the two number-plate lamps. A bulb is a few pounds and a five-minute job.
Shares are the proportion of tests on this vehicle that recorded the item, so they overlap: one test can record several.
What it costs to get a 2022 Tourneo Custom through its MOT
Across the 10 items that are recorded most often on this model, the average repair comes to £30–£79 — and 54% of those repairs are parts that cost under £30.
- Average repair across the 10 common items
- £30–£79
- Cheapest common item: registration plate lamp(s) inoperative in the…
- £5–£20
- Dearest common item: joints constant velocity boot severely…
- £80–£250
- Common items a careful owner can do at home
- 80%
- Repairs that still cost under £30
- 54%
Estimates from typical UK parts prices, weighted by how often each item appears in 5,018 MOT tests on this vehicle. They exclude diagnostics, retest fees and garage labour where the part is a DIY fit, and they are not figures from the DVSA dataset. Older and higher-mileage examples cost more than the average. How these estimates are built → · All MOT repair costs → · Cheapest cars to put through a test →
Every year of the Tourneo Custom, side by side
11 model years on record, from 2015 to 2025. Across them the pass rate runs from 78.7% to 100.0% — a spread of 21.3 points. The bar under each year is the item that failed it most often.
- 2015 78.7% registration plate lamp(s)…
- 2016 82.8% joints constant velocity boot…
- 2017 83.7% pins and bushes pin or bush…
- 2018 85.3% windscreen damaged but not…
- 2019 88.2% windscreen damaged but not…
- 2020 86.3% windscreen damaged but not…
- 2021 85.7% wipers does not clear the…
- 2022 87.0%windscreen damaged but not…
- 2023 92.9% windscreen damaged but not…
- 2024 98.3% srs malfunction indicator lamp…
- 2025 100.0% windscreen damaged but not…
Colour is the pass rate on a fixed scale, so a block means the same thing on any model. Each year links to its own page with the full fault breakdown.
Compare the 2022 Ford Tourneo Custom with another year
The raw pass rate mostly measures age. The year comparison adds the like-for-like figure, the mileage bands and the repair bill.
Other 2022 people carriers with a similar record
Closest pass rates among 2022 people carriers with at least 200 tests, so a small sample cannot flatter itself into the list. Full rankings: best people carriers and worst people carriers.
The full DVSA record for the 2022 Ford Tourneo Custom 10 failure items · 6 advisories · 10 inspection categories · mileage brackets · all of it in the page, none of it above the fold
Every inspection category
Shares of the 4,061 individual items recorded on this vehicle, and the same share across all cars nationally. A single test can record several items, so a row is not a percentage of tests.
| Category | Items | This car | Nationally | Difference |
|---|---|---|---|---|
| Brakes | 1,040 | 25.30% | 20.89% | +4.41 |
| Tyres | 1,017 | 24.80% | 19.76% | +5.04 |
| Lamps, reflectors and electrical equipment | 646 | 15.70% | 12.21% | +3.49 |
| Visibility | 587 | 14.30% | 4.97% | +9.33 |
| Non-component advisories | 276 | 6.70% | 4.18% | +2.52 |
| Suspension | 185 | 4.50% | 20.98% | −16.48 |
| Body, chassis, structure | 121 | 2.90% | 5.57% | −2.67 |
| Noise, emissions and leaks | 79 | 1.90% | 5.52% | −3.62 |
| Identification of the vehicle | 58 | 1.40% | 1.76% | −0.36 |
| Seat belts and supplementary restraint systems | 52 | 1.30% | 0.82% | +0.48 |
The exact failure items, in the tester's words
| Recorded item | Severity | Tests | Est. cost |
|---|---|---|---|
| Windscreen damaged but not adversely affecting driver's view Visibility | Minor | 3.1% | £80–200 |
| Wipers does not clear the windscreen effectively Visibility | Major | 3.0% | £8–22 |
| Registration plate lamp(s) inoperative in the case of multiple lamps or light sources Lamps, reflectors and electrical equipment | Minor | 2.4% | £5–20 |
| Wipers blade defective Visibility | Minor | 2.1% | £8–22 |
| Wipers does not clear the windscreen effectively Visibility | Rectified | 1.9% | £8–22 |
| Brake pads less than 1.5 mm thick Brakes | Major | 1.6% | £18–45 |
| Has a cut in excess of the requirements deep enough to reach the ply or cords Tyres | Major | 1.4% | £45–95 |
| Joints constant velocity boot severely deteriorated Body, chassis, structure | Minor | 1.4% | £80–250 |
| Tyre pressure monitoring system malfunctioning or obviously inoperative Tyres | Major | 1.1% | £45–95 |
| Headlamp not working on dipped beam Lamps, reflectors and electrical equipment | Major | 1.0% | £5–25 |
Severity is as recorded: Major and Dangerous fail the test outright; Minor and Advisory do not. Costs are estimates from typical UK parts prices — see how they are built.
What testers noted without failing the car
Advisories are the early warnings — the same parts a year or two before they fail. Reading them is how you tell a car that has been maintained from one that has been patched.
| Recorded item | Severity | Tests | Est. cost |
|---|---|---|---|
| Brake pads less than 1.5 mm thick Brakes | Advisory | 8.3% | £18–45 |
| Tread depth below requirements of 1.6mm Tyres | Advisory | 6.0% | £45–95 |
| Has a tear, caused by separation or partial failure of its structure Tyres | Advisory | 5.9% | £45–95 |
| Brake discs in such a condition that it is seriously weakened Brakes | Advisory | 4.1% | £45–110 |
| Brake discs significantly and obviously worn Brakes | Advisory | 3.6% | £45–110 |
| Non-component advisories Nail in tyre Non-component advisories | Advisory | 2.2% | £45–95 |
Pass rate by mileage
| Mileage | Tests | Pass rate | Median odometer |
|---|---|---|---|
| 0-30k | 2,039 | 90.4% | 17,502 mi |
| 30-60k | 1,644 | 85.5% | 43,325 mi |
| 60-90k | 938 | 81.3% | 72,485 mi |
| 90-120k | 208 | 88.5% | 102,861 mi |
| 120k+ | 188 | 90.4% | 157,275 mi |
Source: 5,018 recorded tests on this vehicle-year. Every row above is recomputed from the same DVSA extract as the rest of the page — see the methodology.
2022 Tourneo Custom MOT questions
What is the MOT pass rate for a 2022 Ford Tourneo Custom?
87.0% of the 5,018 2022 Ford Tourneo Custom tests in this dataset passed, against a national average of 92.0% for cars first used in 2022. First-attempt pass rate: 85.3%.
What are the most common MOT failures on a 2022 Ford Tourneo Custom?
The three most recorded items are windscreen damaged but not adversely affecting driver's view (3.13%), wipers does not clear the windscreen effectively (2.95%), registration plate lamp(s) inoperative in the case of multiple lamps or light sources (2.39%). Percentages are the share of tests on this vehicle that recorded the item.
Does mileage affect the 2022 Ford Tourneo Custom MOT pass rate?
Yes. Cars under 30,000 miles passed 90.4% of the time, falling to 90.4% for those over 120,000 miles. The median 2022 Ford Tourneo Custom in this dataset had covered 36,917 mi.
Which fuel type is most reliable for a 2022 Ford Tourneo Custom?
Diesel: 86.6% pass rate across 4,400 tests. Other: 87.9% pass rate across 346 tests. Hybrid: 92.6% pass rate across 272 tests. Shares are of the tests on this vehicle that recorded each fuel type.
Does the season affect the 2022 Ford Tourneo Custom MOT pass rate?
Tests recorded in the winter months (October–March) passed 88.1% of the time; summer months (April–September) passed 86.2%. Brakes, tyres and lights are tested harder in bad weather, but the difference is small on most models.